Electric school buses are giving kids a cleaner, but costlier, ride to class

Published

2 years ago

December 10, 2022

admin

BEVERLY, Mass. — It’s a gray November morning, and we’re on board a long, yellow school bus.

The bus bounces over this Boston suburb’s patched streets in a way that would be familiar to anyone who ever rode a bus to class. But the bus is quiet – and not just because there are no kids on board.

This school bus is electric.

Right now, only a tiny fraction of the roughly 480,000 school buses in America are battery-powered. Most still use gasoline or diesel engines, just as they have for decades. But thanks to fast-maturing electric-vehicle technology – and the new incentives available under the Bipartisan Infrastructure Law and the Inflation Reduction Act – electric school buses are set to become much more common over the next decade.

“It’s like a big huge go-kart,” said the bus driver on that November day, who’s been driving school buses, mostly gas-powered, for over three decades. “When you accelerate, you move. When you stop accelerating, you stop. And you don’t hear any sound.”

“Driving a diesel bus is not like driving a go-kart,” she said.

Greener pastures

Environmental activists have been working for years to try to replace diesel and gasoline school buses with new electric models. Until recently, they faced some big challenges: Only a couple of companies made fully electric school buses, prices were very high, and the need for new “refueling” and maintenance infrastructure to replace tried-and-true diesel proved too daunting for many school officials.

That’s starting to change. Over the last couple of years, more companies — including long-established school-bus manufacturers — have begun making electric school buses, government subsidies have increased, and regulators and nonprofits have worked to educate school districts, utilities and the general public about the advantages.

But this isn’t like selling electric vehicles to drivers. School districts have to navigate a confusing array of subsidies and restrictions — and deal with the awkward fact that right now, a new EV bus costs a lot more than a traditional diesel-powered bus (in fact, three to four times as much).

It’s hard to make a battery-electric version of a long-haul truck, like EV startup Nikola is working on, as the batteries required to deliver the distance weigh a lot and take hours to recharge.

But the case for a school bus — which needs only limited range of mileage, and has plenty of idle time to recharge — is much simpler. And the advantages to the traditional buses are clear.

They’re much better, and their savings are much greater once you actually get them into the depot.

Sue Gander

Director at the World Resources Institute

Not only do electric school buses, or ESBs, help the environment — by not expelling diesel fumes or other emissions —they’re also better for the children they carry, particularly those suffering from chronic respiratory conditions such as asthma.

Like other electric vehicles, ESBs are also likely to have lower maintenance costs over time than their internal-combustion counterparts.

Plus, the buses’ large batteries can store and deliver energy to power buildings and other devices, whether temporarily in an emergency or as part of a larger renewable-energy strategy.

Driving up costs

All of those advantages come with a price tag, however.

ESBs are expensive: Battery-electric versions of small “Type A” school buses cost roughly $250,000, versus $50,000 to $65,000 for diesel; full-size “Type C” or “Type D” buses can range from $320,000 to $440,000 in electric form, versus about $100,000 for diesel.

“They’re much better, and their savings are much greater once you actually get them into the depot,” Sue Gander, a former U.S. Environmental Protection Agency official, told CNBC in a recent interview. “But the upfront is such that, without [government] incentives, you can’t break even [in comparison to diesel buses].”

Gander leads the World Resources Institute’s Electric School Bus Initiative, a project funded in part by the Bezos Earth Fund established by Amazon’s founder, Jeff Bezos. The initiative works with school officials, utility companies and ESB manufacturers to try to accelerate the adoption of zero-emission school buses.

“We think for the next three or four years, as costs come down, as scale goes up, we’ll need to have those incentives in place to make the numbers work,” she said.

And like other electric vehicles, ESBs will require new infrastructure: At minimum, a school district or bus operator will need to install chargers and retrain their mechanics to service the new buses’ battery-electric drivetrains and control systems.

A Thomas Built electric school bus in Beverly, Massachusetts.

John Rosevear | CNBC

For small school districts, and those in low-income areas, the costs and challenges can be daunting.

Duncan McIntyre is trying to make it easy, or at least easier, for school districts to go electric. After years in the solar-energy business, he founded a company, Highland Fleets, that aims to make the switch to electric buses simple and affordable for school districts and local governments around the country.

“You’ve got more expensive equipment, but it operates much cheaper,” he said, noting that — as with other EVs — the costs of charging and maintaining an electric school bus are considerably lower than with gas or diesel buses.

The last piece, he says, “which everyone overlooks, is that those bus batteries can send power back to the grid to meet peak demand. And that’s an energy market’s opportunity to create additional revenue.”

Government incentives

The Bipartisan Infrastructure Law passed late last year includes $5 billion in subsides for low- and zero-emission school buses over the next five years.

The EPA, charged with administering those subsidies, said in September about 2,000 U.S. school districts had already applied for the subsidies, with over 90% of those applications requesting electric buses. (The remainder were seeking subsidies for low-emissions buses powered by propane or compressed natural gas, the agency said.)

Not all of those applications, which combined amount to nearly $4 billion in subsidies, will be approved immediately. The EPA awarded about $1 billion in funds in October, giving priority to low-income, rural, and tribal communities. It expects to distribute another $1 billion in 2023.

California offers state-level subsidies, through its Air Resources Board, of up to $235,000 per bus, plus an additional $30,000 per bus for charging equipment. The agency set aside $122 million for the program this year.

Colorado has made available $65 million in funding for a similar program. And New York, Connecticut, Maryland and Maine all moved to set up similar programs this year, with New York the first to target a 100% electric school bus fleet by 2035.

The money is helpful, but Gander said school districts still need to think through all of the aspects of going electric.

“It’s really about supporting school districts, helping them understand where do electric buses fit into my fleet at the moment? And how do I plan for continuing to add them in to my fleet as I go along?” Gander said. “How do I develop the infrastructure? How do I access the funding and financing that’s out there? And how do I involve the community in this process?”

Environment

Tesla launches new Cybertruck RWD for $70,000, removes tons of cool features

Published

4 hours ago

April 11, 2025

admin

Tesla launches new Cybertruck RWD for ,000, removes tons of cool features

Tesla has officially launched a new version of the Cybertruck RWD for $70,000 in the US and Mexico.

It’s more expensive than previously announced and loses a ton of features, but it has more range.

Earlier today, we reported on Tesla unveiling in the Middle East a new ‘Cybertruck Long Range’.

The automaker confirmed that it had a single rear-wheel-drive (RWD) motor, but unlike the previously announced Cybertruck RWD, Tesla said it had 350 rather than 250 miles of range.

Advertisement – scroll for more content

This would point to having the same battery pack as the Dual Motor and Cyberbeast currently available.

At the time, it wasn’t clear if Tesla was launching this specific version for the Middle East or if it was the new Cybertruck RWD to replace the previously announced $62,000 version.

Now, Tesla has opened orders in the online configurator for the US and Mexico of the new Cybertruck Long Range RWD:

It starts at $70,000 before incentive – $9,000 more than the previously announced Cybertruck, but it has 100 more miles on a single charge at 350 miles.

It’s also $10,000 less expensive than the Cybertruck Dual Motor.

You not only lose a motor, but you also lose the powered tonneau. You can buy a “soft tonneau” for $750 and it increases the range to 362 miles:

The new cheaper version also loses the adaptive suspension, the lightbar at the back, the rear screen, and even the bed outlets, according to Tesla’s website.

Tesla says that deliveries are going to start in June.

Electrek’s Take

I might be wrong, but I would assume that the previously announced $61,000 Cybertruck is not going to happen. The Cybertruck is likely proving to be too low-volume to warrant producing different sizes of battery packs.

However, this version might be just to make the $80,000 Cybertruck look better.

It’s not to lose the AWD, the tonneau, the adaptive suspension, and even the bed outlets for $10,000.

These are all pretty essential features of the Cybertruck. I don’t think this version will sell much at $70,000. Maybe they get a few sales of people trying to take advantage of the $7,500 tax credit.

FTC: We use income earning auto affiliate links. More.

Environment

This electric excavator has battery swap tech that lets it recharge in minutes [update]

Published

8 hours ago

April 10, 2025

admin

This electric excavator has battery swap tech that lets it recharge in minutes [update]

The electric construction equipment experts at XCMG just released a new, 25 ton electric crawler excavator ahead of bauma 2025 – and they have their eye on the global urban construction, mine operations, and logistical material handling markets.

UPDATE: telematics announcement.

Powered by a high-capacity 400 kWh lithium iron phosphate battery capable of delivering up to 8 hours of continuous operation, the XE215EV electric excavator promises uninterrupted operation at a lower cost of ownership and with even less downtime than its diesel counterparts.

XCMG is delivering on part of that reduced downtime promise with the lower maintenance and easier repair needs of electric equipment, and delivering on the rest of it with lickety-quick DC fast charging that can recharge the machine’s massive battery in 1.5-2 hours … but that’s not the slick bit. The XCMG XE125EV can be powered up without leaving the job site thanks to its BYD battery swap technology.

Advertisement – scroll for more content

We first covered XCMG and its battery swap technology back in January, and covered similar battery-swap tech being developed by MOOG Construction offshoot ZQUIP, as well – but while XCMG’s battery tech has been in production for several years, it’s still not widely known about in the West (even within the industry).

XCMG showed off its latest electric equipment at the December 2024 bauma China, including an updated version of its of its 85-ton autonomous electric mining truck that features a fully cab-less design – meaning there isn’t even a place for an operator to sit, let alone operate. And that’s too bad, because what operator wouldn’t want to experience an electric truck putting down 1070 hp more than 16,000 lb-ft of torque!?

Easy in, easy out

XCMG battery swap crane; via Etrucks New Zealand.

The best part? All of the company’s heavy equipment assets – from excavators to terminal tractors to dump trucks and wheel loaders – all use the same 400 kWh BYD battery packs, Milwaukee tool style. That means an equipment fleet can utilize x number of vehicles with a fraction of the total battery capacity and material needs of other asset brands. That’s not just a smart use of limited materials, it’s a smarter use of energy.

You can check out all the XE215EV’s specs at this tear sheet, and get an in-person look at the Chinese company’s latest electric excavator this week in Munich, Germany.

Telematics announcement at bauma

XCMG showcases green, smart tech at bauma 2025; via XCMG.

Earlier today, XCMG launched its next-generation Xrea Global Telematics Platform, integrating IoT, big data, cloud computing, and AI to enable what it’s caling, “seamless cross-border fleet management.”

The new telematics platform supports a dozen languages via PC and mobile interfaces, and offers real-time diagnostics, predictive maintenance, and data-driven optimization of both the vehicle and the vehicle’s batteries, empowering equipment managers and fleet operators to track fleets across town, or across time zones.

“XCMG remains committed to advancing engineering technology to empower a sustainable future. Our mission is to deliver efficient, intelligent, and eco-friendly lifecycle solutions for global clients,” said Mr. Yang Dongsheng, Chairman of XCMG Group and XCMG Machinery. “Today, 19% of our product portfolio comprises green innovations under our ‘Green Mountain’ new energy line, with full electrification across all series underway.”

SOURCE | IMAGES: XCMG; via PR Newswire.

FTC: We use income earning auto affiliate links. More.

Environment

Tesla (TSLA) is having a terrible month, and it’s only April 10th!

Published

9 hours ago

April 10, 2025

admin

Tesla (TSLA) is having a terrible month, and it's only April 10th!

On today’s troubling episode of Quick Charge, we explore all the troubles befalling Tesla (and TSLA stock) in the month April – with top executives fleeing the ship, demand plummeting, sales slipping, government incentives at home and abroad under threat, and a raft of receipts brought on by an OpenAI lawsuit hitting the brand, it’s already a bad month for Elon … and there’s still 20 more days to go!

None of this even touches on the $43 million “backlogged” rebate scandal Tesla’s facing in Canada that’s being blamed for people’s negative attitudes about the brand (ha!) or the fact that neither the long-promised Roadster 2.0 or the Tesla Semi will see production anytime this year, either.

The word you’re looking for when you think of Tesla these days is, “cooked.”

Source Links

Prefer listening to your podcasts? Audio-only versions of Quick Charge are now available on Apple Podcasts, Spotify, TuneIn, and our RSS feed for Overcast and other podcast players.

Advertisement – scroll for more content

New episodes of Quick Charge are recorded, usually, Monday through Thursday (and sometimes Sunday). We’ll be posting bonus audio content from time to time as well, so be sure to follow and subscribe so you don’t miss a minute of Electrek’s high-voltage daily news.

Got news? Let us know!
Drop us a line at tips@electrek.co. You can also rate us on Apple Podcasts and Spotify, or recommend us in Overcast to help more people discover the show.

FTC: We use income earning auto affiliate links. More.