Nissan is recalling nearly 10K Ariya EVs over this software defect
Nissan is recalling certain 2023 Ariya electric SUVs over defective inverter software that can cause the vehicle to shut down unexpectedly.
The recall, reported on September 8, impacts 9,813 Ariya vehicles. Based on Nissan’s production records, the issue occurred on certain MY23 Ayiya EVs built between June 17, 2022, and May 19, 2023.
Nissan says on affected vehicles, there’s the potential that conductive shavings from the drive motor’s slip ring can short-circuit the two slip rings.
Because of the short circuit, the inverter detects an overcurrent and cuts the motor torque due to fail-safe protocols. When this happens, the vehicle can shut down unexpectedly with an “EV System Off” message on the dashboard.
The torque will be cut off to the wheels until the fail-safe mode is disabled, requiring the vehicle to be turned off and back on again.
Nissan first noticed the issue in January 2022 during a production trial. The Ariya EV electric motor shut down after the vehicle started moving at a low speed.
After running diagnostics, the DTC revealed a short circuit occurred, but no damage was done. Between February 2022 and April 2022, Nissan inspected Ariya components and discovered the issue.
The company took a closer look at the shavings in the slip ring assembly. However, in late December 2022, Nissan received another report from an Ariya EV in China that shut down.
Over the next few months, Nissan found that the fibers could be generated during usage. Since it was momentary and did not damage any components, Nissan “did not judge this condition as abnormal.”
Nissan implemented improved inverter fail-safe control logic into production in April 2023, receiving three more reports through September 2023.
Out of caution, Nissan is voluntarily recalling the Ariya electric SUVs to update the inverter/motor controller software.
Owners of potentially affected vehicles will be notified beginning on October 20. Dealers will reprogram the inverter to improve protocols free of charge. Nissan says the process may take less than one hour.
Ariya owners can contact Nissan’s customer service at 1-800-867-7669. The recall number is R23C6.
Electrek’s Take
Nissan’s Ariya is built in a new section in its Tochigi assembly plant “intelligent factory,” the automaker’s flagship facility in Japan.
Production has been hampered by supply chain shortages and more, slowing the electric SUVs’ momentum.
The Ariya was expected to hit US showrooms in 2021 but was delayed due to the global chip shortage until late last year. In March, a Reuters report claimed Ariya production was running one-third below planned levels.
This isn’t the first recall, either. In March, Nissan issued a voluntary recall, citing “the steering wheel can detach from the steering column,” impacting over 1,000 Ariya EVs.
Nissan has sold 7,379 Ariya electric SUVs in the US so far this year. Other key markets, including Japan (6,146) and Europe (7,173), show similar results. However, in China, where Nissan sells about a third of its global vehicles, the brand has only sold 1,575 Ariya models in 2023.
FTC: We use income earning auto affiliate links. More.
Honda announced that it is pausing about $15 billion in planned EV investments to build electric vehicle and battery factories in Canada amid uncertainty over trade.
It’s the latest example of Canada’s backing the US plan backfiring.
A few years ago, Canada sided with the US in its plan to save the US auto industry, which was falling behind the rest of the world in the transition to electric vehicles.
Canada agreed to heavily tariff Chinese EVs to keep them away from the North American market, which mainly helps the US auto manufacturing industry, and in return, Canada’s EV production was included in Biden’s IRA to encourage foreign automakers to invest in EV production in both US and Canada to get access to the US market.
However, when Trump came into power earlier this year, he threw a wrench into this entire plan by canceling IRA funding, planning to kill the EV tax credit, and placing tariffs on many countries, including Canada.
It has resulted in planned investments in the EV sector in Canada to cool down.
Now, one of Canada’s most significant EV investments has been paused.
Honda has announced that it is pausing for two years its plan to establish a massive new EV production base in Canada:
“Due to the recent slowdown of the EV market, Honda Motor has announced an approximate two-year postponement of the comprehensive value chain investment project in Canada. The company will continue to evaluate the timing and project progression as market conditions change.”
The investment was announced just over a year ago. It was supposed to include a new EV factory in Ontario and a battery factory, totaling more than $10 billion in investments.
It was supposed to create over 1,000 jobs in Ontario and help retain the 4,200 jobs at Honda’s current assembly plant in Ontario, which are threatened by the electric transition.
Electrek’s Take
Canada is taking a beating here and all for mostly just protecting the US auto industry.
As I have been saying for a while, at this point, you should just invite the Chinese automakers to join.
You can do a deal à la India, where you remove tariffs for Chinese automakers willing to invest in the EV supply chain in Canada.
There’s no point in protecting the US automakers if the US is purposefully destroying the Canadian auto sector.
FTC: We use income earning auto affiliate links. More.
A new company out of Germany called ONOX is bringing sustainable technology to the agriculture industry. After garnering design awards, the ONOX electric tractor prototype is in operation overseas as its makers look to scale and bring its unique modular design, complete with swappable battery packs, to farms everywhere.
It’s been less than two years since ONOX hit the tech scene with a prototype of its flagship electric tractor, which debuted at Agritechnica 2023 in Hanover, Germany. In April of 2024, the German startup’s electric tractor was awarded an iF Design Gold Award.
That same summer, the ONOX1 finalized commissioning before entering an extensive test phase. By December, the startup had snagged another trophy – the Federal Ecodesign Award. This past February, the ONOX electric tractor received road approval in Germany and began operations while the design team continues its mission of making electric agricultural machinery a reality.
The ONOX electric tractor is unique in that it utilizes modular battery swap technology, in which farmers can choose from three different mounting areas (see below).
ONOX’s electric tractor could breathe new life into farming
Since the ONOX electric tractor remains a prototype, many of its specs are targets and estimates, but the initial design is quite impressive. The electric tractor’s motor offers peak power of 70 kW with over 2,400 Nm of torque up front and over 5,500 Nm in the rear. ONOX’s targeted top speed is 40 km/h (~25 mph).
The ONOX tractor features an integrated 20-kWh battery pack and room for additional swappable packs of 30 kWh each. The entire system operates on 48V power, so maintenance is safer and easier for users without further training since there is no risk of exposure to high-voltage components.
The ONOX design team has also integrated an Airline system with mounting rails on the tractor’s hood, enabling future owners to mount cargo, haul hay or produce, or customize the area with other parts. The front of the tractor is also front-loader-ready, adding to its modularity and versatility.
The ONOX website says the electric tractor is self-sufficient using its own solar energy, but from the specs and images we’ve seen, there is no evidence of any solar technology implemented on the current prototype. Perhaps they mean the swappable batteries can be charged using solar when not installed on the tractor.
We will monitor ONOX’s progress as electric tractor development continues en route to commercial sales.
FTC: We use income earning auto affiliate links. More.
Toyota upgraded its electric SUV in just about every way possible. The 2026 Toyota bZ is refined from end to end with a fresh new style, more driving range, advanced new tech, and much more. It even has an NACS port, so you can charge at Tesla Superchargers. Here’s our first look at Toyota’s new EV.
Meet the 2026 Toyota bZ electric SUV
Remember the bZ4X? It’s currently the only EV Toyota sells in North America. It’s now called the “bZ,” and it’s better than ever.
The 2026 Toyota bZ has an estimated driving range of 314 miles, a 25% improvement over the outgoing bZ4X. It also has a built-in NACS charging port, unlocking access to Tesla’s vast Supercharger network across North America.
Toyota said the upgraded EV can charge from 10% to 80% “under ideal conditions” when using DC fast charging. With added Plug & Charge capabilities, charging has never been easier.
The AWD models now have up to 338 hp, a 50% improvement thanks to new SIC semiconductors. Front-wheel-drive (FWD) models deliver 221 hp, up from 201 HP in the 2025 bZ4X.
Other upgrades, including battery pre-conditioning and a thermal management system, help optimize charging speeds in cold weather.
Battery options and driving range
The 2026 Toyota bZ will have two battery options: 57.7 kWh and 74.7 kWh. Toyota estimates that the larger (74.7 kWh) battery will provide up to 314 miles of range, while the smaller (57.7 kWh) option will get up to 236 miles.
Toyota upgraded the electric SUV inside and out. The exterior features Toyota’s new “hammerhead front end,” which is shown on updated vehicles like the Camry and Crown. The new styling includes redesigned front overfenders and slim LED daytime running lights.
The interior received a few upgrades, including a redesigned center console. The setup now includes a larger 14″ Toyota Audio Multimedia touchscreen, two wireless phone chargers, and a slimmed-down dashboard.
Standard features include a 7″ driver display screen, heated front and rear seats, regenerative braking, Toyota Safety Sense 3.0, and more.
Upgrading to the Limited trim will gain you 20″ black alloy wheels, multi-LED headlights, SofTex®-trimmed seats, ventilated front seating, and added safety/ driver assist features. Other options include a panoramic moonroof with power sunshade (XLE) and a premium 9-speaker JBL Audio system (Limited).
.
| 2026 Toyota bZ trim | Battery | Range (Manufacturer estimated) |
| XLE FWD | 57.7 kWh | 236 miles |
| XLE FWD Plus | 74.7 kWh | 314 miles |
| XLE AWD | 74.7 kWh | 288 miles |
| Limited FWD | 74.7 kWh | 299 miles |
| Limited AWD | 74.7 kWh | 278 miles |
According to Toyota, the new name will help simplify things for buyers. We suspect it’s also designed to revamp the brand’s sole EV after a slow (to say it nicely) rollout in North America. The bZ4X was recalled shortly after launch over concerns that the wheels may fall off.
The 2026 Toyota bZ is expected to arrive at dealerships in the second half of 2025. Check back for more info as prices will be revealed soon.
With the upgraded 2026 model arriving, Toyota is offering close-out prices on the 2024 and 2025 bZ4X. The 2024 bZ4X is listed with up to $19,000 in lease cash, while 2025 models can be leased for as low as $269 per month. You can use our link to find deals on the 2024 and 2025 Toyota bZ4X in your area today.
FTC: We use income earning auto affiliate links. More.
-
Sports3 years ago‘Storybook stuff’: Inside the night Bryce Harper sent the Phillies to the World Series
-
Sports1 year agoStory injured on diving stop, exits Red Sox game
-
Sports2 years agoGame 1 of WS least-watched in recorded history
-
Sports2 years agoMLB Rank 2023: Ranking baseball’s top 100 players
-
Sports4 years ago
Team Europe easily wins 4th straight Laver Cup
-
Environment2 years agoJapan and South Korea have a lot at stake in a free and open South China Sea
-
Environment2 years agoGame-changing Lectric XPedition launched as affordable electric cargo bike
-
Business3 years agoBank of England’s extraordinary response to government policy is almost unthinkable | Ed Conway